Open the app

Bulkhead Workshop › Land Rover models › Range Rover Evoque L538 2.0 Ingenium diesel › Workshop guide

Range Rover Evoque L538 2.0 Ingenium diesel workshop guide

Range Rover Evoque L538 (2011–18) · 2015–2018

15 maintenance jobs for a Range Rover Evoque L538 2.0 Ingenium diesel, each with the parts, genuine part numbers, tools and steps.

Work safely: support the vehicle on axle stands, never a jack alone; let it cool first. Check figures against your workshop manual. You do this work at your own risk.

ENGINE · EVERY 21,000 MI / 2 YRS

Service: engine oil & filter

The core of every Land Rover service. Modern turbo engines and DPFs depend on the exact oil specification, not just the viscosity.

Many specialists halve this interval on high-mileage diesels, short-trip cars and anything that tows.

Parts
  • Engine oil (0W-20 or 0W-30 low-ash synthetic to the STJLR specification on the filler cap; ≈5.5 L)
  • Oil filter (to suit engine) LR073669
  • Sump plug washer (or sump plug and washer) LR073675
Tools
  • Drain tray
  • Socket set
  • Filter housing socket
  • Torque wrench
  • Diagnostic tool to reset the service indicator

Steps

  1. Warm the engine, park level, and lift or raise the vehicle safely (on air suspension, select the jacking/workshop mode first so it does not move under you).
  2. Remove the engine undertray. Drain the oil and renew the sump plug washer (some engines need a new plug).
  3. Renew the filter: cartridge types unscrew the housing cap; fit the new O-rings supplied and tighten the cap to the torque on it.
  4. Refill with 0W-20 or 0W-30 low-ash synthetic to the STJLR specification on the filler cap. Start, check for leaks, then check the level after a few minutes on the dipstick or in the instrument menu (≈5.5 L).
  5. Reset the service indicator with the menu or a diagnostic tool, and log the service here.
BODY · EVERY 21,000 MI / 2 YRS

Pollen (cabin) filter

A blocked filter weakens the blower and mists the windows.

Parts
  • Pollen filter LR056138
Tools
  • Trim tools

Steps

  1. Find the filter (behind the glovebox or under the scuttle panel, depending on model).
  2. Note the airflow arrow, fit the new one the same way.
FUEL & AIR · EVERY 42,000 MI / 4 YRS

Air filter element

Turbo engines lose power and economy, and the airflow sensor gets dirty, when the filter blocks.

Bulkhead uses every second service; check your Maintenance Check Sheet for your exact vehicle.

Parts
  • Air filter LR071942 (from VIN GH000001)
Tools
  • Screwdrivers / Torx

Steps

  1. Release the airbox lid and lift out the element.
  2. Wipe out the box, check the seal, fit the new element so it seats all round.
  3. Check the intake ducts for splits. Inspect more often in dusty use.
FUEL & AIR · EVERY 42,000 MI / 4 YRS

Diesel fuel filter

Common-rail pumps and injectors are ruined by water and dirt.

Bulkhead uses every second service; some markets and engines need it more often.

Parts
  • Fuel filter
Tools
  • Socket set
  • Container
  • Diagnostic tool (some engines)

Steps

  1. Clean around the filter. Drain the water trap first if fitted.
  2. Renew the element and seals.
  3. Prime the system: on most of these engines, switch the ignition on and off several times (without starting) so the in-tank pump fills the filter. Some need a diagnostic tool routine.
  4. Start and check for leaks; clear any fuel codes.
ENGINE · EVERY 21,000 MI / 2 YRS

Auxiliary belt & tensioner check

On many of these engines the auxiliary belt drives the water pump and alternator; a snapped belt can be pulled into the timing belt cover.

Parts
  • Auxiliary belt (if cracked)
Tools
  • Torch

Steps

  1. Check the belt for cracks, missing ribs and glazing.
  2. Check the tensioner holds steady with the engine running and the pulleys run quietly.
ENGINE · EVERY 21,000 MI / 2 YRS

DPF & EGR health check

Short trips stop the particulate filter regenerating. A blocked DPF puts the engine into limp mode and can dilute the oil with diesel.

Parts

None

Tools
  • Diagnostic tool with live data

Steps

  1. Check for any DPF or engine warnings.
  2. Read the soot loading and regeneration history with a diagnostic tool.
  3. If you mostly do short trips, drive at a steady speed on a main road for 20–30 minutes every week or two.
  4. Check the oil level is not rising (a sign of fuel dilution from failed regenerations).
ENGINE · EVERY 3 MONTHS

AdBlue level check

If the AdBlue tank runs dry the engine won't restart.

Parts
  • AdBlue (ISO 22241)
Tools
  • Funnel

Steps

  1. Check the range in the instrument menu.
  2. Top up through the blue filler with ISO 22241 AdBlue only.
COOLING · EVERY 10 YRS

Coolant change (10-year)

Land Rover renews the coolant every 10 years regardless of mileage. Check the level and strength every service.

Parts
  • Antifreeze concentrate (OAT antifreeze to Land Rover spec)
  • Hoses & clips (if needed) (replace any soft, swollen or cracked hoses)
Tools
  • Drain tray
  • Garden hose
  • Screwdrivers
  • Hydrometer or refractometer

Steps

  1. Work on a cold engine only. Remove the expansion tank or radiator cap slowly.
  2. Open the radiator drain (or remove the bottom hose) and the cylinder block drain tap or plug. Set the heater to hot.
  3. Flush with clean water until it runs clear. Squeeze every hose: replace any that feel soft, crunchy or swollen.
  4. Check the radiator fins, fan blades and (where fitted) the viscous coupling. A viscous fan should turn with some resistance when the engine is warm.
  5. Refill with a 50% antifreeze mix (OAT antifreeze to Land Rover spec). Fill slowly to avoid air locks; on coil-sprung models use the bleed screw on the thermostat housing or radiator top where fitted.
  6. Run the engine to working temperature with the cap off (or loose), top up as the level drops, refit the cap and check again when cold.
BRAKES · EVERY 21,000 MI / 2 YRS

Brakes, tyres & suspension inspection

Heavy vehicles with big wheels wear pads, discs and tyres quickly.

Parts
  • Brake pads (if under 3 mm)
  • Brake discs (if under minimum)
Tools
  • Jack and stands (or a lift)
  • Vernier
  • Torch

Steps

  1. Check pad thickness and disc condition on every wheel (many models also have pad wear sensors).
  2. Check tyres for wear, damage and age; check the spare.
  3. Look for leaks at the dampers, and check ball joints and bushes for play.
  4. Check brake pipes and hoses for corrosion and chafing.
BRAKES · EVERY 3 YRS

Brake fluid change

Land Rover renews brake fluid every 3 years regardless of mileage.

Parts
  • Brake fluid (DOT4 low-viscosity brake fluid to Land Rover spec (ESP/ABS systems))
Tools
  • Pressure bleeder
  • Diagnostic tool (ABS bleed routine on some models)

Steps

  1. Bleed each wheel in the order in your workshop manual.
  2. Some models need an ABS bleed routine run with a diagnostic tool.
  3. Check the pedal is firm before driving.
TRANSMISSION · EVERY 60,000 MI / 6 YRS

Automatic gearbox fluid & differentials

Land Rover lists these fluids as long-life (changed at 10 years on many models). Specialists change the automatic gearbox fluid and filter, and the diff oils, sooner on a vehicle that tows or is kept beyond its warranty.

Bulkhead's advisory interval. The official Land Rover interval is longer; check your Maintenance Check Sheet.

Parts
  • ATF (ZF Lifeguard fluid for ZF gearboxes)
  • Gearbox sump pan / filter (to suit gearbox; the sump pan includes the filter on the 8-speed)
  • Differential oil (Land Rover-specified fluid)
Tools
  • Socket set
  • Fluid pump
  • Diagnostic tool (to read fluid temperature)

Steps

  1. The ZF automatics are filled at a set fluid temperature (about 35–45 °C) with the engine running: you need a diagnostic tool to read it.
  2. Renew the sump pan or filter and refill to the level plug as the workshop manual describes.
  3. Drain and refill the front and rear differentials (and the transfer unit/PTU on transverse-engined models).
TRANSMISSION · EVERY 36,000 MI / 3 YRS

Haldex coupling oil & filter

The coupling that sends drive to the rear axle relies on clean oil and a working pump. Neglect leaves the vehicle front-drive only and can damage the rear drive unit.

Many specialists advise this every 3 years or so; Land Rover's own schedule is longer.

Parts
  • Haldex coupling oil (Land Rover / Haldex-specified fluid)
  • Haldex filter (if fitted)
Tools
  • Socket set
  • Fluid pump

Steps

  1. Drain the coupling and clean or renew its filter where fitted.
  2. Refill with the specified fluid.
  3. Check the rear diff and PTU for leaks while you're under there.
BODY & CHASSIS · EVERY 1 YR

Underbody & corrosion check

Subframes, brake pipes and (on the Discovery 3/4 and Sport L320) the steel frame corrode in salty winters.

Parts
  • Cavity wax / underbody protection
Tools
  • Torch
  • Pressure washer

Steps

  1. Wash the underside, then check the subframes, frame rails, brake and fuel pipes, and the rear arches.
  2. Treat any bare metal and re-wax cavities.
SAFETY · EVERY 1 YR

Annual safety inspection

Do this before the MOT and you will rarely fail.

Parts
  • Bulbs & fuses (spares, if needed)
  • 2 × Wiper blades (if worn)
Tools
  • Helper
  • Tyre gauge

Steps

  1. Lights: every light works, including brake lights, indicators, reverse light and number plate light.
  2. Wipers and washers clear the screen. Horn works.
  3. Seat belts latch, retract and are not frayed. Seat mounts are secure.
  4. Exhaust: no blows and the mountings are secure.
  5. Tyres: tread depth, cuts, bulges and age. Check the spare too.
  6. Brakes pull up straight and the handbrake holds on a hill.
SAFETY · EVERY MONTHLY

Monthly walk-round checks

Five minutes a month catches leaks and low levels before they become repairs.

Parts

None

Tools
  • Tyre gauge
  • Torch

Steps

  1. Engine oil on the dipstick between the marks.
  2. Coolant level (check cold), brake and clutch fluid levels, washer fluid.
  3. Tyre pressures (including the spare) and look for cuts.
  4. Look under the vehicle where it has been parked. Note the colour of any drips: brown/black = oil, green/blue/orange = coolant, red = ATF or PAS, clear and slippery = brake fluid.
  5. All lights work.

Track your own Land Rover

Add your vehicle to Bulkhead Workshop to see what is due now, tick off jobs as you go, keep a service history and order the parts in one basket. It is free and saved in your own browser.

Open Bulkhead Workshop